冷藏货柜服务

冷藏货柜服务

澳博体育app下载:冷藏集装箱的先驱

澳博体育app下载 has a long history with refrigerated container shipping in the Pacific. 其冷藏货物的创新处理始于1900年,其持续改进的精神导致了航运业中最好的冷藏集装箱系统之一. Careful consideration of customers’ needs resulted in the following standard features:

  • 温度 control to within less than one degree
    Precise control for transporting extremely temperature-sensitive cargo such as pharmaceuticals
  • Availability of Modified Atmospheres to limit cargo respiration rate
    Reduces or eliminates the presence of carbon dioxide, 氮, and /or oxygen to reduce or eliminate spoilage from interaction with these gases; single insertion of atmosphere at time of loading; most effective for short-duration voyages
  • The use of substitute atmospheres for Controlled Atmosphere applications
    通过在航行期间保持替代气氛进一步延缓成熟
  • 澳博体育app使用最先进的密封技术来建造和测试澳博体育app的冷藏集装箱
    澳博体育app下载的冷藏集装箱在运输过程中最大限度地减少了大气的损失,控制气氛系统在运输过程中保持选定的气氛,直到集装箱打开
  • 特殊设计,最大限度减少皮重
    Content weight can be maximized on inland transportation
  • Length and height choices to accommodate a variety of needs
    几种集装箱长度和两种高度提供了根据货物类型和所需包装密度的总货物容量选择
  • Motor- generators for inland shipping where no other power is available
    温度 control continues during Port to Door inland transportation
  • 远程冷藏箱监控
    On-board operators can check refrigerated container conditions using an on-board PC:

    • 温度
    • 所需警报
    • 上传单位温度的长期历史记录

这些功能都旨在提供最高水平的冷藏产品质量和完整性, 以及运输过程中的最大有效载荷, whether ocean transit or inland trucking to the final destination.


温度控制backtop

现代冷藏集装箱将最大容量和气流与精确的温度控制相结合,在整个负载期间提供均匀的保护. 澳博体育app下载的设备可以将温度控制在初始温度设置的一定程度内(这是药品运输的关键要求), 例如). 还有“双区”装置,允许在同一容器中进行两种不同程度的冷却.


大气中修改backtop

美森拥有专门建造和装备的环境改造(MA)和环境控制(CA)应用的集装箱. 该设备在容器正面设有端口,以方便特定大气气体有效流动进入容器,同时迫使氧气和其他存在的气体排出.

改良大气(MA)

All refrigerated products require protection from heat, 冷或某些气体, 包括氧气, to impede deterioration of the goods and chemical reactions with gases. 应托运人要求, 美森可以安排几家领先的技术公司在澳博体育app的集装箱内提供改良空气.

受控大气(CA)

更长的运输时间, 受控大气在整个运输过程中保持一定水平的替代大气,以减缓自然成熟过程. 这使得农产品被装入集装箱更接近装运日期,从而使农产品在田间成熟的时间更长, 使它们在目的地的价值更高. 可控气氛是另一种由领先技术公司提供的产品,将在原产地港插入澳博体育app特别设计的集装箱中.

进一步了解澳博体育app的 大气中修改 Service Provider procedures 从奥克兰到长滩.


概述-温度控制容器 backtop

澳博体育app下载提供40英尺和20英尺的冷藏集装箱,以满足澳博体育app横跨澳博体育app下载的运输需求. 该设备能够处理横跨澳博体育app下载的冷藏和冷冻货物,以保护货物的完整性和质量.

In addition to our expansive container inventory, 澳博体育app下载有一个大的, diversified chassis inventory to meet customer needs (excluding 那霸 and 中国 services). 底盘设计包括标准的固定底盘, 专用滑轴底盘, 以及专门的三轴底盘. The latter two designs increase the weight that may be transported over roads.

See the specific refrigerated container sizes below for each service.


冷藏电源和发电机组backtop

大多数澳博体育app下载冷藏箱都是双电压的, 从而节省了分离成本, dual-voltage transformers mounted at the shipper’s facility.

While our equipment is in transit between the port and the customer’s facility, depending on the commodity and distance traveled, power for the reefers can be provided by 澳博体育app下载’s chassis-mounted, under-slung, diesel-powered generators which provide 220 / 440-volt, three-phase electric power when away from a normal power source. 电机发电机增加了集装箱和底盘的重量,为了符合公路上的重量限制,必须将这种额外的重量考虑到集装箱的装载中.


前阶段评审backtop

澳博体育app澳博体育app那里收到设备后,所有美森的设备都要经过一个清洁和校准的过程. 这个过程, 也被称为旅行前, 是在每次货物移动之后和设备离开码头装载新货物之前完成的吗. 校准是一个过程,需要检查的单位,以确定它是在良好的工作秩序. When this process is completed, the unit is set at a standard temperature of 35 degrees.


温度设置 & 电机发电操作说明backtop

发电机组启动说明

开机前,发电机组断路器(CB1)和制冷机组都应处于OFF状态. 启动后, 发电机组在给制冷机组供电前,应至少运行2分钟,使电源稳定. 这将消除任何冷启动瞬态尖峰到达制冷机组的可能性. 冷启动瞬态尖峰可能会对对电尖峰或瞬态敏感的制冷机组造成麻烦的过电压警报.

警告

  • Beware of moving poly V-belt, belt-driven components, and hot exhaust components.
  • 在任何情况下,都不应将乙醚或任何其他未经授权的起动辅助装置与进气加热器一起使用.

请注意

Piston rings in engines that have operated less than 100 hours may not be fully seated. This may lead to the possibility of oil seepage from the exhaust pipe. To properly seat the rings, operate the engine under full load for a period of 24 hours. If the condition persists, check valve clearance when the engine is cold.

标准单位使用说明

  • Make sure that Circuit Breaker CB-1 is in the OFF position.
  • Hook up the 460-volt cable from the refrigerated unit to the Genset receptacle.
  • Hold the Intake Heater Switch (HS) in the PREHEAT position. Suggested hold times for a cold engine are as follows:
环境温度 Time
26°C (78°F) 5秒
0至26°C(32至78°F) 10秒
-8至26°C(18至32°F) 20秒
低于-8°C(8°F) 30秒
  • With the Intake Heater Switch (HS) held in the PREHEAT position, place the Ignition Switch (IGN) in the START position.
  • 发动机启动后, 继续将进气加热器开关(HS)保持在预热位置,直到发动机产生足够的油压以关闭油压安全开关(大约5秒)。. 被释放后, 进气加热器开关(HS)将自动回到OFF位置,加热器将保持通电3分钟.

自动启动装置使用说明

  • Make sure that Circuit Breaker CB-1 is in the OFF position.
  • Hook up the 460-volt cable from the refrigerated unit to the Genset receptacle.
  • Place the Ignition Switch (IGN) in the RUN position.
  • If the Low Coolant Sensor (LCS) is immersed in coolant, 自动重启模块将使加热器通电30秒,安全蜂鸣器将响起. After the 30 second delay, the unit will attempt to start.

后起动检查

  • Allow the Genset unit to run for at least 2 minutes.
  • 接通断路器CB-1.
  • 用电压表检查发电机输出, voltage output at startup with no load at 50Hz operation should be 1500 RPM, 360 - 460年休假. Voltage output may vary and fall with ISO specifications based on ambient.
  • 启动制冷机组.
  • Run the engine for 10 minutes (check total time meter operation).
  • Listen for abnormal bearing noise (AC generator).
  • Check the fuel lines, lube oil lines, and filters for leaks.
  • 检查排气系统是否有泄漏.

停止指令

  • 将断路器CB-1置于OFF位置.
  • Place the Ignition Switch (IGN) in the OFF position.

 

冷藏的指令

连接电源

! 警告

  • Do not attempt to remove power plug(s) before turning OFF the Start-Stop switch (ST), 单元断路器, 还有一个外部电源.
  • Make sure the power plugs are clean and dry before connecting to the power receptacle.

连接到380/460 VAC电源

  • Make sure the Start-Stop switch (ST), located on the control panel, is in “0” position (Off).
  • 确保断路器CB-1, 位于控制盒内, is in “0” position (Off).
  • Plug the 460 VAC (yellow) cable into a de-energized 380/460 VAC, 三相电源, 接通电源.
  • 将断路器CB-1置于“I”位置(On).
  • 关闭并固定控制箱门.

连接到190/230 VAC电源

To allow unit operation on nominal 230-volt power, an autotransformer is required. 自变压器配有230 VAC电缆和插座,以接受标准460 VAC电源插头. The 230-volt cable is black in color while the 460-volt cable is yellow. The transformer may also be equipped with a circuit breaker (CB-2). The transformer is a step-up transformer that provides 380/460 VAC, 三相, 50/60 Hz power to the unit when the 230 VAC power cable is connected to a 190/230 VAC, 三相电源.

过程

  • Make sure the Start-Stop switch (ST), located on the control panel, is in “0” position (Off).
  • 确保断路器CB-1, 位于控制盒内, 和CB-2, 位于变压器上, 都处于“0”位置(关闭).
  • Plugin and lock the 460 VAC power plug at the receptacle on the transformer.
  • Plug the 230 VAC (black) cable into a de-energized 190/230 VAC, 三相电源, 接通电源.
  • Set circuit breakers CB-1 和CB-2 to “I” position (On).
  • 关闭并固定控制箱门.

为 questions and concerns please contact our 澳博体育app服务 Center Refrigerated Group 1-800-662-8766.


澳博体育app服务backtop

In order to meet the requirements of our customer's shipping temperature-sensitive cargo, 美森已经建立了一个全国销售和澳博体育app服务团队,以满足澳博体育app运输冷藏集装箱. 澳博体育app的全国冷藏货物销售团队可以为整个大陆和整个岛屿的澳博体育app提供支持. 如需销售或澳博体育app支持,请致电 1 - 800 - 9 -澳博体育app

" class="hidden">myechinese易校园